Synthesis of Silica using Silk Sericin without Hydrolysis of Tetraethyl Orthosilicate
Synthesis of Silica using Silk Sericin without Hydrolysis of Tetraethyl Orthosilicate
International Journal of Industrial Entomology. 2013. Dec, 27(2): 298-302
Copyright © 2013, Korean Society of Sericultural Science
  • Received : December 12, 2013
  • Accepted : December 12, 2013
  • Published : December 31, 2013
Export by style
Cited by
About the Authors
Ji Young Lee
National Instrumentation Center for Environmental Management, Seoul National University, Seoul 151-921, Korea
Ki Hoon Lee
Research Institute for Agriculture and Life Sciences, Seoul National University, Seoul 151-921, Korea
In this study, the effect of sericin on synthesis of the silica was investigated. Using the mixture of sericin solution and tetraethyl orthosilicate (TEOS), it was confirmed that silica could be synthesized in the presence of sericin, which was verified by thermal gravimetric analysis (TGA), Fourier-transformed infrared spectrometer (FT-IR) and nuclear magnetic resonance spectrometer (NMR) analysis. The TGA and FT-IR data revealed that silica-sericin complex was formed as a final product. Based on the TGA result, the content of silica and sericin in the complex would be 87 and 13%, respectively. The degree of silica condensation was higher than the natural biosilica. It could be concluded that sericin can induce the synthesis of silica directly from TEOS, which is similar to silicatein from marine sponges.
Silica is the second abundant element in the biosphere and many organisms utilize it as a structural component (Rupcich et al ., 2003). Diatom is the one of the example, which synthesizes silica and protects their cell structure with it (Fuhrmann et al ., 2004). Marine sponges also synthesize silica and their spicules are made of it (Cha et al ., 1999). These organisms condense silicic acid into silica, and the process is mediated by several proteins.
Silaffin is a protein from in diatoms and is known to facilitate the silica synthesis (Kröger et al ., 2001). Moreover, it can control the morphology of the synthesized silica (Sumper et al ., 2006). On the other hand, silicatein which derives from marine sponges is an enzyme that catalyzes the silica synthesis directly from the silica precursor (Shimizu et al ., 1998). In both proteins, serine plays an important role in the silica synthesis. Silaffin has high content of serine which is phosphorylated by post-translational modification (Kröger et al ., 2002). In the case of silicatein, serine is located at the active center (Cha et al ., 2000). This gave us an idea to use sericin for the silica synthesis because sericin has also high content of serine.
Sericin is a minor protein that is secreted by the silkworm. It bonds two brins of fibroin fiber together and make able to maintain the shape of cocoon. Sericin is usually discarded by the degumming process but could be used as new source of biopolymer, because it is easy to extract and able to get in large quantities. Currently sericin is used as an ingredient of cosmetics (Kim et al ., 2009) and new application are found in pharmaceutical, polymeric, and biomedical field (Zhaorigetu et al ., 2001; Kwak et al ., 2013; Oh et al ., 2011). Previously, sericin has been used to induce the biomineralization of hydroxy apatite (Takeuchi et al, 2008). In this study, we used sericin in order to synthesize the silica. The synthesis of silica was verified with various analytical methods.
Materials and Methods
- Materials
Silk cocoon was obtained from Hung Jing Co., LTD. (Seoul, Korea). All other chemicals were purchased from Sigma-Aldrich LTD. (Yongin, Korea).
- Preparation of hot-water extracted sericin solution
Silk cocoons were boiled with distilled water using an autoclave at 120℃ for 1 h. The solution was filtered with a nonwoven filter in order to remove the remaining silk fibers. The solution was freshly made every time before the experiment. The final concentration of sericin was 1 %(w/v).
- Synthesis of silica using sericin
The synthesis of silica was performed by mixing tetraethyl orthosilicate (TEOS) and sericin solution. More precisely, 500 μL of TEOS and 500 μL of sericin solution were added in a Eppendrof tube, and it was shaken vigorously with an orbital shaker. The tube was incubated at room temperature without further stirring. After 1 wk, 400 μL of ethanol was added to the mixture and centrifuged at 10,000g for 1 min in order to precipitate the reactant. The precipitate was further washed with ethanol 3 times. The collected precipitate was dried in a vacuum chamber for 36 h in order to remove residual ethanol.
- Analysis of precipitate
The formation of silica was verified by thermal gravimetric analysis (TGA, Q-5000 IR, TA-Instrument, USA), Fourier transformed-infrared spectrometer (FT-IR, MIDAC, Japan) and 29 Si nuclear magnetic resonance spectrometer (NMR, AVANCE, Bruker, Germany). The heating rate of TGA was 10˚C/min and the data in the range of 100-600˚C were collected under nitrogen gas purging. In the case of FT-IR, the spectrum was obtained from KBr method after 24 scans and the resolution was 4 cm -1 . Solid-state 29 Si MAS NMR spectra were acquired on a DSX- 400 NMR spectrometer (Bruker, Germany) operating at 79.5 MHz. Detailed conditions were as follows: spinning rate, 3.5 kHz; pulse length, 4.2 μs; recycle delay, 30 s. Field emission scanning electron microscope (FE-SEM, SUP-RA55 VP, Carl Zeiss, Germany) was employed to observe the microscopical morphology of the precipitate.
Results and Discussion
We prepared sericin solution by the hot-water extraction method. Sericin solution was added to TEOS and left in the chamber without stirring for 1 wk at room temperature. The TEOS and the sericin solution did not mix each other ( Fig. 1 a), and a white precipitate was formed only at the interface between the TEOS and the sericin solution. In order to improve the precipitation, we stirred the reaction tube vigorously. A dispersion of the two liquid was formed in the sericin layer and maintained through the incubation time. The white precipitate was grown in the sericin solution layer during 1 wk of incubation ( Fig. 1 b). Fig. 1 c shows the final precipitate obtained after washing and drying.
In order to verify the synthesis of silica, we first performed TGA analysis. While sericin decomposes over 200℃, the weight loss of precipitates was about 15% even at 600℃ indicating the formation of silica ( Fig. 2 ). In the case of the precipitate, there was a significant loss of weight between 200~400℃ which was the same temperature range that the thermal degradation of sericin occurs. Therefore, the precipitate might be a complex of silica and sericin. Based on the TGA results, the weight percent of silica and sericin in the complex would be 87 and 13%, respectively.
The formation of silica-sericin complex could be also verified by the ATR-FTIR results ( Fig. 3 ). The asymmetric stretch, symmetric stretch and bending vibration of Si-O-Si at 1100, 800
PPT Slide
Lager Image
Optical images of TEOS and sericin solution mixture before mixing (a) and after 1 wk of incubation (b). The final precipitate after washing and drying is shown in (c).
and 450 cm -1 , respectively, could be observed in the ATR-FTIR spectrum (Siuzdak et al ., 1999). At the same time, a characteristic peak of amide I (1650 cm -1 ) and amide II (1530 cm -1 ) could be observed (Teramoto et al ., 2005). This result also indicates that the precipitate is a complex of silica and sericin.
The synthesis of silica can be also verified by the NMR. Generally, Q n notation (Q 1 , Q 2 , Q 3 and Q 4 ) is used to identify the environment of silicon atom, and n indicates the number
PPT Slide
Lager Image
TGA curves of silica-sericin complex and sericin.
PPT Slide
Lager Image
FT-IR spectrum of silica-sericin complex.
of siloxane bonds connecting a silicon atom with other silicon atoms via oxygen bridges. In NMR, the resonance signal of Q 2 , Q 3 and Q 4 appears at δ ≈ -92, -101 and -110 ppm, respectively (Bertermannm et al ., 2003; Cong et al ., 1993). All 3 peaks could be found in the NMR spectrum indicating the synthesis of silica ( Fig. 4 ). The Q 4 /Q 3 ratio indicates the degree of silica condensation, and it was 2.28 which are higher than the natural iosilica ( Table 1 ).
Fig. 5 shows the FE-SEM image of silica-sericin complex. It had a fractal structure where sphere-like particles having tens of nanometer size are agglomerated into large and irregular shapes.
PPT Slide
Lager Image
Solid phase 29Si MAS NMR spectrum of silica-sericin complex.
Quantitative analysis of Q2, Q3, and Q4peaks in silicasericincomplex.
PPT Slide
Lager Image
a: from Bertermannm et al. (2003)
PPT Slide
Lager Image
FE-SEM image of silica-sericin complex. (×15000)
Generally, TEOS is hydrolyzed under acidic or basic condition to in order to synthesize silica through sol-gel process. However, the present study shows that silica could be synthesized directly from TEOS without any hydrolysis. It seems that the role of sericin during silica formation is similar to silicatein. Further application of the synthesized silica nano- and microparticles in biomedical field is under investigation. Expected area is drug delivery and tissue engineering where silicatein is currently applied (Schröder et al ., 2007).
This research was supported by Basic Science Research Program through the National Research Foundation of Korea(NRF) funded by the Ministry of Education(NRF-2009-0072366).
Bertermannm R , Kröger N , Tacke R (2003) Solid-state 29Si MAS NMR studies of diatioms: structural characterization of biosilica deposits Anal Bioanal Chem 375 630 - 634
Cha JN , Shimizu K , Zhou Y , Christiansen SC , Chemlka BF , Stucky GD , Morse DE (1999) Silicatein filaments and subunits from a marine sponge direct the polymerization of silica and silicones in vitro. P Natl Acd Sci USA 96 361 - 365
Cha JN , Stucky GD , Morse DE , Demlng TJ (2000) Biomimetic synthesis of ordered silica structures mediated by block copolypeptides. Nature 403 289 - 292
Cong X , Kirkpatrick RJ (1993) 29Si MAS NMR spectroscopic investigation of alkali silica reaction product gels Cement Concrete Res 23 811 - 823
Fuhrmann T , Landehr S , Rharbi-kuchi ME , Sumper M (2004) Diatom as living photonic crystals. Appl Phys B 78 257 - 260
Kim MK , Oh H , Lee JY , Lee JY , Lee KH (2009) Enzymatic Hydrolysis of Silk Sericin and its Anti-oxidative Effect. J Soc Cosmet Scientists Korea 35 135 - 141
Kröger N , Deutzmann R , Sumper M (2001) Silica-precipitating peptide from diatoms. J Biol Chem 276 26066 - 26070
Kröger N , Lorenz S , Brunner E , Sumper M (2002) Self-assembly of highly phosphorylated silaffins and their function in biosilica morphogenesis. Science 18 584 - 586
Kwak HW , Yang YS , Kim MK , Lee JY , Yun HS , Kim MH , Lee KH (2013) Chromium(VI) adsorption behavior of silk sericin bead. Int J Indust Entomol 26 47 - 53
Oh H , Kim MK , Lee KH (2011) Preparation of sericin microparticles by electrohydrodynamic spraying and their application in drug delivery. Macromol Res 19 266 - 272
Rupcich N , Goldstein A , Brennan JD (2003) Optimization of sol-gel formulations and surface treatments for the development of pin-print protein microarrays. Chem Mater 15 1803 - 1811
Schröder HC , Brandt D , Scholoßmacher U , Wang X , Tahir MN , Tremel W , Belikov SI , Müller WEG (2007) Enzymatic production of biosilica glass using enzymes from sponges: basic aspects and application in nanobiotechnology (material sciences and medicine). Naturwissenshchaften 94 339 - 359
Shimizu K , Cha J , Stucky GD , Morse DE (1998) Silicatein a: Cathepsin L-like protein in sponge biosilica. P Natl Acd Sci USA 95 6234 - 6238
Siuzdak DA , Kenneth A , Mauritz (1999) Surlyn®/[Silicon Oxide] hybrid materials. 2. physical properties chacterization. J Polym Sci B Polym Phys 37 143 - 154
Sumper M , Brunner E (2006) Learning from diatoms: nature’s tools for the production of nanostructured silica. Adv Funct Mater 16 17 - 26
Takeuchi A , Ohtsuki C , Kamitakahara M , Ogata S , Miyazaki T , Tanihara M (2008) Biomimetic deposition of hydroxyapatite on a synthetic polypeptide with β-sheet structure in a solution mimicking body fluid. J Mater Sci 17 378 - 393
Teramoto H , Miyazawa M (2005) Molecular orientation behavior of silk sericin film as revealed by ATR infrared spectroscopy. Biomacromolecules 6 2049 - 2057
Zhaorigetu S , Sasaki M , Watanabe H , Kato N (2001) Supplemental silk protein, sericin, suppresses colon tumorigenesis in 1,2 z-dimethylhydrazine-treated mice by reducing oxidative stress and cell proliferation. Biosci Biotechnol Biochem 65 2181 - 2186